2025 (2) 2

https://doi.org/10.15407/polymerj.47.02.059

RHEOLOGICAL PROPERTIES OF HYDROGELS AGAR-AGAR WITH SODIUM CHLORIDE AND CITRIC ACID

VLADISLAV GONCHARUK (ORCID: 0000-0002-2835-1270), ANATOLII MAKAROV (ORCID: 0000-0001-6077-4006), LIUBOV DUBROVINA⃰ (ORCID: 0000-0002-1094-3294), IRYNA POTAPCHUK (ORCID: 0000-0001-7226-3051)

A.V. Dumansky Institute of Colloid and Water Chemistry of the NАS of Ukraine, 42 Akademika Vernadskoho Blvd., Kyiv, 03142, Ukraine  

^⃰e-mail: dubrovina@ua.fm

Polimernyi Zhurnal, 2025, 47, no. 2: 59–67

Section: Structure and properties.

Language: Ukrainian.

Abstract:

The rheological properties of composite hydrogels of agar-agar with sodium chloride (0.03 wt.%), citric acid (0.3 wt.%), and their mixture (at the same concentrations of additives) were studied. The hydrogels were obtained by heating the initial solutions with and without a constant magnetic field (created by a ferrite permanent magnet with a magnetic flux of at least 0.02 Mwb built into the magnetic stirrer), and then cooling them at room temperature in a Rheotest RV2 cylinder. For hydrogels obtained by heating without a magnetic field, it was shown that the addition of NaCl leads to an increase in viscosity over the entire range of shear stresses and an increase in yield strength from 14.3 Pa to 42.8 Pa. Adding citric acid reduces the viscosity and yield strength to 11.4 Pa. When a mixture of citric acid and NaCl is added to the gel, its viscosity is higher in almost the entire range of shear stresses (up to about 25 Pa) than the gel containing only agar-agar, which has a yield strength of 14.3 Pa. The flow curves of all gels contain maxima, indicating the non-equilibrium nature of the system and the presence of large aggregates in the structure within a certain range of shear rates. These aggregates break down into individual macromolecules of the polymer components of agar-agar with a further increase in shear rate. The degree of syneresis during freezing and thawing was determined gravimetrically for samples frozen at −18°C and thawed at room temperature. Introducing additives leads increases hydrogel syneresis from 46% to 90%, depending on the gels’ composition and the number of freeze-thaw cycles. The worst results were observed for the gel with the addition of citric acid. It was shown that hydrogels obtained using a magnetic field have lower viscosity for all additives, and their viscosity is significantly lower than that of gels obtained without a magnetic field. Maxima on the flow curves are present only for the agar-agar gel and the gel with the addition of NaCl. The yield strength is 11.8, 11.9, and 1.6 Pa for gels with agar-agar, with the addition of NaCl, and citric acid, respectively. When a mixture of NaCl and citric acid is added, the gel does not exhibit solid-state properties, and no yield strength is observed.

Keywords: hydrogels, rheological properties, magnetic field, agar-agar, sodium chloride, citric acid, syneresis.

REFERENCES

1. Bashir S., Hina M., Iqbal J., Rajpar A.H., Mujtaba M.A., Alghamdi N.A., Wageh S., Ramesh K., Ramesh S. Fundamental concepts of hydrogels: synthesis, properties, and their applications. Polymers, 2020, 12, 11: 2702–2762. https://doi.org/10.3390/polym12112702.
2. Akhtar M.F., Hanif M., Ranjha N.M. Methods of synthesis of hydrogels… A review. Saudi Pharmaceutical Journal, 2016, 4, 5: 554–559. https://doi.org/10.1016/j.jsps.2015.03.022.
3. Gholamali, I. Stimuli-responsive polysaccharide hydrogels for biomedical applications: a review. Regenerative Engineering and Translational Medicine, 2021, 7: 91–114. https://doi.org/10.1007/s40883-019-00134-1.
4. Armisen R., Galatas F. Production, properties and uses of agar, Chapter 1. In book: Production and Utilization of Products from Commercial Seaweeds Ed.: D.J. McHugh: FAO fisheries technical paper, 1987, 288: 1–57.
5. Gumenyuk O.L. Kharchovi dobavky. Teksty lekcii dlia studentiv. Chernigiv: ChNTU, 2014: 157.
6. Sirohman I.V., Zavgorodnya V.M. Harchovi dobavki: navch. posibnyk / Tovaroznavstvo kharchovyh produktiv funktsionalnogo pryznachennia. Kyiv: Tsentr uchbovoi literatury, 2009: 360.
7. Feiner G. Additives: phosphates, salts (sodium chloride and potassium chloride, citrate, lactate) and hydrocolloids, Chapter 1. In book: Meat Products Handbook: Practical Science and Technology / Boca Raton Boston New York Washington: Woodhead Publishing Limited and CRC Press LLC, 2006: 72–88.
8. Goncharuk V.V., Dubrovina L.V. Rheological Properties and Water-Retaining Power of Agar Hydrogels with Carboxymethyl Cellulose. Russian Journal of Applied Chemistry, 2020, 93, 7: 1019–1126. https://doi.org/10.1134/S1070427220060113.
9. Uriev N.B. Physicochemical dynamics of disperse systems. Russian Chemical Reviews, 2004, 73, 1: 37–58. https://doi.org/10.1070/RC2004v073n01ABEH000861.
10. Bertula, K., Martikainen, L., Munne, P., Hietala, S., Klefström, J., Ikkala, O., Nonappa, N. Strain Stiffening of Agarose Gels. ACS Macro Letters, 2019, 8, 6: 670¬–675. https://doi.org/10.1021/acsmacrolett.9b00258.
11. Rüther A., Forget A., Roy A., Carballo C., Mießmer F., Dukor R.K., Nafie L A., Johannessen C., Shastri V.P., Ludeke S. Unravelling a Direct Role for Polysaccharide b -Strands in the Higher Order Structure of Physical Hydrogels. Angewandte Chemie, 2019, 56, 16: 4603–4607. https://doi.org/10.1002/anie.201701019.
12. Aymard P., Martin D.R., Plucknett K., Foster T.J., Clark A.H., Norton I.T. Influence of Thermal History on the Structural and Mechanical Properties of Agarose Gels. Biopolymers, 2001, 59, 3: 131−144. https://doi.org/10.1002/1097-0282(200109)59:3<131:AID-BIP1013>3.0.CO;2-8.
13. Asyakina L.K., Dyshlyuk L.S. Study of viscosity of aqueous solutions of natural polysaccharides. Science Evolution, 2016, 1, 2: 11–19. https://doi.org/10.21603/2500–1418–2016–1–2–11–19.
14. Moritaka H., Shimada A. Effects of sodium chlorideon rc-carrageenan the sol-gel transition of agar and gellangum. Journal of Home Economics of Japan, 2006, 57, 6: 393–401.
15. Moritaka H., Takahashi M., Kubota K.. Effects of Cooling Rate and Sodium Chloride on Polysaccharide Gelation. Food Science and Technology Research, 2007, 13, 4: 345–350.
https://doi.org/10.3136/fstr.13.345.
16. Lipatov Yu.S. Colloid Chemistry of Polymers, Elsevier Sci. Ltd., Amsterdam (1988).
17. Frenkel Ya.I. Kineticheskaya teoriya zhidkostey. L:Nauka, 1975: 592.
18. Chirapart A., Ohno M., Ukeda H., Sawamura M., Kusuno H. Effects of partial acid hydrolysis on physical and chemical properties of agar from a newly reported Japanese agarophyte (Gracilariopsis lemaneiformis). Journal of Applied Phycology, 1997, 9, 1: 73–76. https://doi.org/10.1023/A:1007985610421.
19. Demchenko D.V., Pozharitskaya O.N., Shikov A.N., Flisyuk E.V., Rusak A.V., Makarov V.G. Rheological Study of Agar Hydrogels for Soft Capsule Shells. Pharmaceutical Chemistry Journal, 2014, 47, 10: 556–558. https://doi.org/10.1007/s11094-014-1004-z.
20. Divoux T., Mao B., Snabre P. Syneresis and delayed detachment in agar plates. Soft Matter, 2015, 11, 18: 3677–3685. https://doi.org/10.1039/C5SM00433K.
21. Boral S., Saxena A., Bohidar H.B. Syneresis in agar hydrogels International. Journal of Biological Macromolecules, 2010, 46, 2: 232–236. https://doi.org/10.1016/j.ijbiomac.2009.12.008
22. Prasad K., Siddhanta A.K., Rakshit A.K., Bhattacharya A., Ghosh P.K. On the properties of agar gel containing ionic and non-ionic surfactants. International Journal of Biological Macromolecules, 2005, 35, 3–4: 135–144. https://doi.org/10.1016/j.ijbiomac.2005.01.004.
23. Kimura T. Reviews study on the effect of magnetic fields on polymeric materials and its application. Polymer Journal, 2003, 35, 11: 823–843. https://doi.org/10.1295/polymj.35.823.
24. Tsukruk V.V., Shilov V.V. Structure of Polymeric Liquid Crystals. Kyiv: Nauk. Dumka, 1990: 256.
25. Yamamoto I., Matsumoto Y., Yamaguchi M., Shimazu Y., Ishikawa F. Magnetic field effects on sol-gel phase changes in aqueous polymers. Physica B: Condensed Matter, 1998, 246–247: 408-411. https://doi.org/10.1016/S0921-4526(97)00948-4.
26. Garrido L. Magnetic orientation of diamagnetic amorphous polymers. Journal of Polymer Science J. Part B. 2010. 48, 10: 1009–1015. https://doi.org/10.1002/polb.21989.
27. Kuznetsova S. Yu. Magnitnye svojstva vody. Uspekhi sovremennogo estestvoznaniia, 2010, 10: 49–51.
28. Shipunov B.P., Markin V.I. Abnormal rheology of agar-agar solutions prepared using water
exposed to an electromagnetic field. Russian Journal of Bioorganic Chemistry, 2021, 47: 1404–1410 https://doi.org/10.1134/S1068162021070141.